프로펠러는 선박의 핵심요소중의 하나이다. 선박용 프로펠러재료의 강도향상에 대해 얼마간 연구가 진행되고 있다. 그러나 프로펠러재료의 피로수명 확률분포의 예측과 파라미터의 영향의 평가에 관한 연구는 눈에 띄지 않는다. 본 연구에서는 몬테카를로 시뮬레이션에 의한 선박용 프로펠러재의 피로수명 확률분포 평가 시스템을 개발하고, 또한, 피로수명의 분포에 영향을 미치는 제반 파라미터의 영향을 논하고자 한다. 얻어진 결과는 다음과 같다. 1. 선박용 프로펠러재료로 이용되는 HBsC1과 AlBC3 두 재료 모두 젯 치즐에 의한 피닝에 의해 피로수명이 증가되었다. 그러나 수명의 분포형상은 크게 변화가 없었다. 2. 번 응력진폭 의 증가로 수명분포는 증가한다. 수명분포는 응력이 작을 때 응력의 변동계수에 의해 크게 영향을 받지 않는다. 이 충분히 커졌을 때 의 변동계수가 증가함으로써 수명분포가 증가한다. 그리고 수명분포는 특이한 양상을 나타냈다. 의 변동계수가 증가할 때 낮은 확률의 영역에서 수명분포는 증가한다. 그러나 높은 확률의 영역에서 수명분포는 감소한다. 3. 수명분포에 대한 절편 A의 평균치의 영향은 작다. A의 변동계수가 증가할 때 수명분포는 증가한다. 4. 손상비율인자 의 변동계수가 증가할 때 피로수명분포가 증가한다. 이 조건에서 응력진폭의 값은 수명분포의 형태에 대해 거의 영향을 미치지 않는다. 5. 가 작을 때 응력 불학실성인자 의 변동계수의 수명분포에 대한 영향을 작다. 가 충분히 클 때 의 변동계수가 증가함으로써 낮은 확률 영역에서는 수명분포가 증가하고 높은 확률 영역에서는 감소하는 현상을 나타냈다.
A propeller has been considered as one of the most critical elements in propelling ships. Many researchers have made a lot of progress in studying the strength improvement of marine propeller materials. However, studies on a parametric sensitivity and probabilistic distribution of fatigue life of propeller materials have not been made yet. In this study, a computer system has been developed to predict the probabilistic distribution of fatigue life of propeller materials by using Monte Carlo simulation, and the influence of several parameters on the life distribution is discussed and the results obtained from this study are as follow: 1. The fatigue life of both of the materials, HBsC1 and AlBC3, increased after the air jet chisel peening in the same conditions. However, all of the life distribution shape were not largely changed. That is, the quantitative change of life distribution with and without peening was not so notable. 2. The distribution of the life is increasing as alternating stress increasing. The distribution of the life are not largely affected by the COV of as was small. The life distribution is increasing as the COV of is increasing when was large enough. And the shape of the life distribution is very special. As the COV of is increasing, the life distribution is increasing in the region of the low probability, however the life distribution is decreasing in the region of the high probability. 3. The influence of the mean intercept for life distribution is small. However, the life distribution is increasing as the COV of is increasing. 4. The distribution of fatigue life is increasing as the COV of damage ratio factor is increasing. And the value of alternating stress almost has no effect for the shape of life distribution in this condition. 5. When was small, there was small difference on the life distribution shape as the COV of stress uncertainty factor changed. But the life distribution is increasing in the region of the low probability and is decreasing in the region of the high probability as the COV of increased when was large enough.